Chevrolet Lanos (since 2004 release)
1. Car device
2. Recommendations about operation
3. Malfunctions in way
4. Maintenance
4.1. General provisions
4.2. Daily Service (DS)
4.3. First maintenance (TO-1)
4.3.1. Check and adjustment of a tension of a belt of the drive of the generator and pump of the hydraulic booster of steering
4.3.2. Check and adjustment of a tension of a belt of the drive of the compressor of the conditioner
4.3.3. Check of a belt of the drive of the gas-distributing mechanism
4.3.4. Replacement of oil in the engine and an oil filter
4.3.5. Cleaning of system of ventilation of a case
4.3.6. Check of hoses and connections of the cooling system
4.3.7. Check of system of production of the fulfilled gases
4.3.8. Check of tightness of fuel-supply lines
4.3.9. Replacement of the fuel filter
4.3.10. Replacement of the filtering element of the air filter
4.3.11. Check and adjustment of the drive of switching off of coupling
4.3.12. Check of level and a dolivka of oil in the transmission
4.3.13. Check of protective covers of drives of forward wheels
4.3.14. Check of technical condition of details of a forward suspension bracket on the car
4.3.15. Check of technical condition of details of a back suspension bracket on the car
4.3.16. Check and adjustment of angles of installation of wheels
4.3.17. Survey and check of steering on the car
4.3.18. Check of a free wheeling (side play) of a steering wheel
4.3.19. Check of tightness of a hydraulic actuator of brakes
4.3.20. Check of degree of wear of brake shoes, disks and drums
4.3.21. Check of operation of the vacuum amplifier of brakes
4.3.22. Check of overall performance of the brake system
4.3.23. Check of the parking brake
4.3.24. Service of the rechargeable battery
4.3.25. Replacement and service of spark plugs
4.3.26. Check and adjustment of light of headlights
4.3.27. Body fittings lubricant
4.3.28. Clearing of drainage openings
4.4. Second maintenance (TO-2)
5. Engine
6. Transmission
7. Running gear
8. Steering
9. Brake system
10. Electric equipment
11. Body
12. Wheels and tires
13. Purchase of spare parts
14. A trip on HUNDRED
15. Winter operation of the car
16. Preparation for checkup
17. Advice to the beginning mechanic
18. Appendices
19. Schemes of electric equipment
 








4-3-22-proverka-ehffektivnosti-raboty-tormoznojj-sistemy.html

4.3.22. Check of overall performance of the brake system

It is desirable to check overall performance of the brake system at special brake stands (similar to the applied traffic polices when carrying out annual technical inspection of cars). As a last resort approximate complex evaluation of the work of the brake system can be executed on the flat horizontal platform closed for traffic. It is desirable that the platform was evenly covered with a thin layer of sand.
The inspection described below can be carried out only on the cars which are not equipped with ABS. If your car is equipped with anti-blocking system, then it is better to address on HUNDRED.
Accelerate the car without loading (in salon only the driver) on the I transfer to speed about 15 km/h. Sharply press a brake pedal to block wheels, and do not release it to a full stop of the car.
Go out of the car and examine the brake marks left by car wheels. If brake traces of forward wheels are slightly longer back, and length of traces is identical at the left and on the right, then the brake system is serviceable. Otherwise repair system.



Проверка эффективности работы тормозной системы
Fig. 4.4. Check of overall performance of the brake system
    
NOTE
The following ratios (fig. 4.4) have to be observed:
L lion. lane = L rights. lane.
L lion. задн. = L rights. задн.
L Lane> L задн.
    
PREVENTION
Do not abuse similar assessment because it is connected with the increased unilateral wear of tires.

"previous page
4.3.21. Check of operation of the vacuum amplifier of brakes
following page"
4.3.23. Check of the parking brake